My Garage

Popular searches

Safety recalls

Peugeot 807 safety recalls

Every road vehicle recall DVSA lists for the Peugeot 807 since 1992: what the problem is, how it is put right, how many vehicles it covers and when they were built. Newest first.

Recalls for the Peugeot 807. Also see car recalls by year and make.

Last updated
Records analysed
21 recalls matched to this model
Methodology
View methodology
  • Recalls since 1992 21 launched 2003 to 2015
  • Most recent 9 December 2015 DVSA recall R/2015/241
  • Recalls 2016 to 2025 0 launched in those ten years
  • Busiest year 2010 4 recalls launched

Does a recall affect your Peugeot 807?

Not every Peugeot 807 is affected. Each recall covers cars built on particular dates or with particular VINs, which DVSA’s file does not list in full. To check a specific car, use GOV.UK’s vehicle recall check with its registration, or ask the manufacturer or a dealer, who can check the VIN.

Peugeot 807 recalls by year

Recalls launched each year, 2003 to 2026

2010 had the most, with 4. A count of recalls is not a measure of safety: one recall can cover a handful of cars or tens of thousands.

Peugeot 807 safety recalls by year of launch
Year Recalls
’03 3
’04 2
’05 2
’06 3
’07 1
’08 2
’09 0
’10 4
’11 1
’12 1
’13 1
’14 0
’15 1
’16 0
’17 0
’18 0
’19 0
’20 0
’21 0
’22 0
’23 0
’24 0
’25 0
’26 0

Source:DVSA,UK Motoring analysis January 1992 to September 2026 Updated

Every Peugeot 807 recall, newest first

2015 1 recall

Fuel may leak

Launched 9 December 2015 DVSA recall R/2015/241 Manufacturer ref. ZZV

Defect
The fuel heating device integrated in to the diesel fuel filter cover may be defective and allow heat to build up within the electrical supply connector causing the cover to distort and air to enter the fuel circuit. This could make the vehicles difficult to start and a warning light will be illuminated on the dash board. The engine could be difficult or not possible to start. In the worst cases a diesel fuel leak could eventually appear.
Remedy
Recall the vehicles that are likely to be affected and replace the fuel heater cover. Additionally the electrical connector will be inspected and where necessary replaced.
Vehicles affected
12,833 across everything the recall covers
Built
3 Sept 2012 to 19 Dec 2014

2013 1 recall

Potential for reduced steering control

Launched 31 August 2013 DVSA recall R/2013/096 Manufacturer ref. ZLF

Defect
The steering column link bolt which retains the steering wheel to the steering column may not have been tighten to the correct specification. This can result in a gradual increase in movement between the steering wheel and shaft with an associated rattle. This should identify the issue to the driver however if the driver does not heed this warning then the steering control of the vehicle could be reduced.
Remedy
Recall all affected vehicles to check and if required re-torque the steering column link bolt.
Vehicles affected
71 across everything the recall covers
Built
14 Jun 2011 to 25 Nov 2011
Also covers

2012 1 recall

Tyre may deflate

Launched 28 April 2012 DVSA recall R/2012/041 Manufacturer ref. ZEJ

Defect
Some tyres may have suffered superficial damage when the vehicle was being transported. The front Left hand tyre may have localised damage on the tread or the inner side. The tyre may rip and deflate.
Remedy
Carry out a visual check of the condition of the tyre in the affected areas and replace the tyre if necessary.
Vehicles affected
14 across everything the recall covers
Built
30 Jan 2012
Also covers

2011 1 recall

Power steering assistance may fail.

Launched 11 July 2011 DVSA recall R/2011/083 Manufacturer ref. ZAM

Defect
It is possible that the wiring harness for the power assisted steering motor may come in contact with other components in the engine bay. Should this occur then it is possible that the power steering assistance on this large vehicle may become affected.
Remedy
Recall affected vehicles and fit protection to the wiring harness.
Vehicles affected
1,577 across everything the recall covers
Built
1 Feb 2010 to 7 Feb 2011
Also covers

2010 4 recalls

Braking assistance may not perform correctly

Launched 16 December 2010 DVSA recall R/2010/222 Manufacturer ref. YWY

Defect
In very rare circumstances the vacuum pump one way valve may not function correctly which could affect the level of braking assistance.
Remedy
Recall the vehicles that are likely to be affected to replace the brake vacuum pump one way valve.
Vehicles affected
24,220 across everything the recall covers
Built
15 Dec 2006 to 31 Mar 2009

Lights may fail without warning.

Launched 6 October 2010 DVSA recall R/2010/157 Manufacturer ref. YWB

Defect
It has been identified that the position of the exterior lighting control ring may not be detected by the lighting management system and the lights may switch off without warning.
Remedy
Recalled vehicles will have the lighting management software updated.
Vehicles affected
2,903 across everything the recall covers
Built
6 Jul 2007 to 7 Mar 2008

Braking efficiency may be compromised

Launched 10 August 2010 DVSA recall R/2010/114 Manufacturer ref. YWR

Defect
The threaded portion of the brake linkage rod in the brake control system may not be to conformity. This could result in a reduction of braking efficiency.
Remedy
Recall affected vehicles to check rod and replace if found not to meet conformity.
Vehicles affected
386 across everything the recall covers
Built
24 Feb 2010 to 3 Jun 2010
Also covers

Vehicle exterior lights may fail without warning

Launched 4 January 2010 DVSA recall R/2009/157 Manufacturer ref. YSD

Defect
The lighting management system may incorrectly detect the position of the exterior lighting control switch. This may cause the exterior light to switch off without warning.
Remedy
Recall all affected vehicles and install a new version of the exterior lighting management software to the vehicle.
Vehicles affected
635 807 vehicles
Built
1 Jul 2007 to 27 Mar 2008

2008 2 recalls

Diesel fuel return pipe may abrade and wear.

Launched 16 July 2008 DVSA recall R/2008/106 Manufacturer ref. ynu

Defect
It has been identified that a slight amount of play in the diesel fuel return pipe mountings on certain vehicles may over time lead to abrasion and wear of the pipe.
Remedy
Recalled vehicles will have the subject clips checked and the pipe secured.
Vehicles affected
2,323 across everything the recall covers
Built
Build dates not given

Reduced braking performance

Launched 1 February 2008 DVSA recall R/2008/015 Manufacturer ref. YNMYNLYMKYMJYKLYFQ

Defect
It has been identified that on the specified vehicles a fault may develop with the brake vacuum pump. This can result in hardening of the brake pedal with an attendant loss of braking efficiency.
Remedy
Recalled vehicles will have the vacuum pump replaced.
Vehicles affected
19,867 across everything the recall covers
Built
1 Jul 2005 to 31 Dec 2006

2007 1 recall

Possibility of brake fluid leakage.

Launched 4 October 2007 DVSA recall R/2007/144

Defect
It has been identified that the heat shield which protects the exhaust system may contact one of the rear brake hoses. In extreme situations this may cause leakage within a brake circuit which would be represented by extended brake pedal travel.
Remedy
Recalled vehicles will be checked for heat shield to brake hose contact and if necessary the shield will be adjusted. The brake hose will be replaced if rubbing contact has been made.
Vehicles affected
20 807 vehicles
Built
Build dates not given
DVSA lists it as
“807 EW10J4”

2006 3 recalls

Seat belt bracing action may be affected

Launched 11 April 2006 DVSA recall R/2006/064

Defect
The seat belt locking action may not be as fast as it is designed to be.
Remedy
Recall the vehicles that may be affected to check the date of manufacture of the seat belts and where necessary replace the seat belts.
Vehicles affected
37 across everything the recall covers
Built
16 Dec 2005 to 19 Dec 2005
Also covers

Braking efficiency may be affected

Launched 10 April 2006 DVSA recall R/2006/061 Manufacturer ref. X8L

Defect
Braking assistance could be adversely by freezing of moisture that may accumulate in the vacuum circuit.
Remedy
Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.
Vehicles affected
16,530 across everything the recall covers
Built
Build dates not given
Also covers

Fuel may leak

Launched 23 February 2006 DVSA recall R/2006/041 Manufacturer ref. X9D

Defect
Due to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.
Remedy
To address the issue recalled vehicles will receive an engine management download.
Vehicles affected
4,338 across everything the recall covers
Built
Build dates not given

2005 2 recalls

Brake circuit may leak

Launched 8 September 2005 DVSA recall R/2005/177 Manufacturer ref. X8K

Defect
Under certain circumstances a brake pipe may chafe on the turbo charger air intake securing clip. In extreme situations the wear caused could lead to leakage within a brake circuit and the illumination of the red brake warning light.
Remedy
Recalled vehicles will be checked for the chafe condition and if necessary the turbo air intake securing clip will be relocated. The affected brake pipe will also be changed if it displays any sign of wear.
Vehicles affected
1,898 807 vehicles
Built
Build dates not given

Airbag system may malfunction

Launched 13 June 2005 DVSA recall R/2005/084 Manufacturer ref. X7E

Defect
Some cases have been found where inadequate drainage of water condensing from the air conditioning system has caused water to run under the carpet. This in turn may lead to the airbag warning light coming on or in extreme cases lead to airbag systems malfunctioning.
Remedy
Recall the vehicles that are likely to be affected for modification of the drainage tube and the anti return valve.
Vehicles affected
6,304 807 vehicles
Built
Build dates not given

2004 2 recalls

Failure of the throttle stop could lead to a reduction in braking assistance

Launched 9 July 2004 DVSA recall R/2004/117 Manufacturer ref. X5G

Defect
The original engine software may cause erratic operation of the motorised throttle body. This could in rare extreme cases cause the throttle stop to break. This will cause the engine to revert to limp home mode which possible may cause a reduction in braking assistance.
Remedy
Install updated software in the engine ECU.
Vehicles affected
8,599 across everything the recall covers
Built
Build dates not given
Also covers

Risk of fire - heater blower module

Launched 10 March 2004 DVSA recall R/2004/011 Manufacturer ref. X3Q

Defect
There is a possibility of defective components in the heater blower which could cause a short circuit and loss of ventilation of the passenger compartment and in an extreme condition could set fire to the wiring harness.
Remedy
Recall affected vehicles and replace heater blower module
Vehicles affected
168 807 vehicles
Built
10 May 2001 to 10 Jan 2003

2003 3 recalls

Water ingress into the airbag ECU

Launched 5 September 2003 DVSA recall R/2003/123 Manufacturer ref. XZW

Defect
There is a possibility that water may ingress into the airbag electronic control unit (ECU) compartment. This may cause premature deployment of the airbag.
Remedy
Seal the airbag ECU compartment.
Vehicles affected
326 807 vehicles
Built
19 Jan 2001 to 3 Dec 2002

Electrical signal could neutralise the sliding door safety lock

Launched 5 September 2003 DVSA recall R/2003/122 Manufacturer ref. XZW

Defect
There is a possibility that the electric sliding doors may open whilst the vehicle is in motion.
Remedy
Fit a replacement electronic control unit to the door.
Vehicles affected
326 807 vehicles
Built
19 Jan 2001 to 3 Dec 2002

Rear bench seat may not lock in place

Launched 22 August 2003 DVSA recall R/2003/137 Manufacturer ref. X1M

Defect
Rear bench seat in third row may not lock in place and tip forward during harsh deceleration
Remedy
Recall affected vehicles and modify routing of check strap.
Vehicles affected
3 807 vehicles
Built
6 Dec 2002 to 30 Jan 2003

Data sources and methodology

Datasets used on this page
Figures Source Period Records Updated
Safety recalls Vehicle safety recalls Driver and Vehicle Standards Agency
Derived statistics UK Motoring 		January 1992 to September 2026 21 recalls matched to this model 15 September 2026
  • Road vehicle recalls (DVSA numbers starting R/) whose model names match the Peugeot 807. DVSA records some recalls under a range or chassis name we cannot match, so this list may be incomplete.
  • Vehicles affected is the number the manufacturer reported to DVSA. When one recall covers several models, DVSA often gives only the total.
  • Build dates are the periods the manufacturer gave. Some recalls have none. VINs are not shown.
  • Concerns written in capitals have been put in sentence case, and apostrophes lost in DVSA’s file have been put back. The text is otherwise DVSA’s.
How we calculate these figures All data sources

Contains public sector information licensed under the Open Government Licence v3.0.