2025 MOT results
Volvo S80 common problems
The most common reason a Volvo S80 fails its MOT is a sidelight out, on 15.1% of its 1,924 failed tests in 2025. Against other cars of the same age, 4 faults stand out, the widest gaps being: a tyre worn through to the cords at 7.0% of failures against 4.1% expected; headlamp aim set too low at 6.8% of failures against 4.0% expected; worn brake pads at 7.1% of failures against 4.6% expected.
- Tests in 2025 6,207 Cars aged three and over
- Failed first time 31.0% 1,924 tests
- Found a dangerous defect 8.3% Unsafe to drive away
- Ended with an advisory 58.9% A problem to watch, not a failure
What fails a Volvo S80 MOT
Each bar is the share of failed Volvo S80 tests with that defect. Where we can compare it with cars of the same registration years, the marker shows what an average car of those ages records (12 of the 12 items below).
Most common reasons for failure
A test can fail for more than one defect, so shares add up to more than 100%.
| Defect | Share of failed tests |
|---|---|
| Position lamp: not working Lamps, reflectors and electrical equipment | 15.1% |
| Brake pads: less than 1.5 mm thick Brakes | 7.1% |
| Tyres: ply or cords exposed Tyres | 7.0% |
| Headlamp aim: too low Lamps, reflectors and electrical equipment | 6.8% |
| Drive shafts: constant velocity boot split or insecure, no longer prevents the ingress of dirt Body, chassis, structure | 6.5% |
| Track rod end: ball joint has excessive play Steering | 6.3% |
| Tyres: tread depth below requirements of 1.6mm Tyres | 5.8% |
| Registration plate lamp(s): inoperative in the case of a single lamp or all lamps Lamps, reflectors and electrical equipment | 5.8% |
| Washers: provides insufficient washer liquid Visibility | 5.3% |
| Headlamp: not working on dipped beam Lamps, reflectors and electrical equipment | 5.0% |
| Malfunction indicator lamp: inoperative or indicates a malfunction Noise, emissions and leaks | 5.0% |
| Parking brake efficiency below requirements Brakes | 5.0% |
Source:DVSA,UK Motoring analysis 2025 Updated
-
Sidelight out
15.1% of failures 11.9% expected somewhat more often
A sidelight, also called a position lamp, not working. It marks the width of the car at night.
Walk round the car with the lights on and the hazards going; these are the cheapest failures to avoid.
-
Worn brake pads
7.1% of failures 4.6% expected 1.5 times as often
Friction material worn under 1.5mm, thinner than the point most manufacturers call the limit.
Look through the wheel spokes at the pad against the disc; wear indicators squeal before they get this far.
-
Tyre worn through to the cords
7.0% of failures 4.1% expected 1.7 times as often
The tyre is worn or damaged far enough to expose the cords underneath, which is a dangerous defect.
Run a hand round the inner and outer walls of each tyre, which is where kerbing shows.
-
Headlamp aim set too low
6.8% of failures 4.0% expected 1.7 times as often
The dipped beam points lower than it should, so it lights too little of the road.
Nothing to do at the roadside, but a garage resets the aim in minutes; a sagging suspension corner or a heavy boot load can throw it out.
-
Split joint boot
6.5% of failures 6.1% expected about as expected
A split rubber boot on a joint or driveshaft. The joint may still be sound, but dirt and water get in once the boot is open.
Turn the wheels to full lock and look behind them for greasy splits in the rubber concertina.
-
Worn steering or suspension joint
6.3% of failures 4.2% expected 1.5 times as often
Play in a steering or suspension joint, where a worn ball and socket lets the wheel move where it should not.
A knock at low speed over rough ground, or vague steering, is the usual warning.
Which parts of the car fail
Lamps, reflectors and electrical equipment is the area that most often fails a Volvo S80, on 45.4% of failed tests. The widest gap against cars of the same registration years is steering, on 12.1% against 8.2% expected.
Failure categories
DVSA's own sections of the test. The marker is what cars of the same registration years record.
| Defect category | Share of failed tests |
|---|---|
| Lamps, reflectors and electrical equipment | 45.4% |
| Suspension | 25.1% |
| Brakes | 23.8% |
| Tyres | 20.1% |
| Body, chassis, structure | 13.4% |
| Visibility | 13.1% |
| Steering | 12.1% |
| Noise, emissions and leaks | 8.4% |
Source:DVSA,UK Motoring analysis 2025 Updated
What testers warn about
58.9% of Volvo S80 tests ended with at least one advisory: a fault the tester found that did not fail the test. On Volvo S80s, these are the items to ask about on a car you are viewing, because they are what the last tester expected to go next.
Most common advisories
Share of all tests, passes included.
| Advisory | Share of tests |
|---|---|
| Tread depth: worn close to legal limit or worn on edge Tyres | 20.8% |
| Suspension arms: pin or bush worn but not resulting in excessive movement Suspension | 10.5% |
| Brake discs: worn, pitted or scored, but not seriously weakened Brakes | 9.9% |
| Coil spring: corroded Suspension | 9.3% |
| Brake pads: wearing thin Brakes | 8.1% |
| Tyres: slightly damaged or cracking or perishing Tyres | 7.7% |
| Engine oil leak, but not excessive Noise, emissions and leaks | 6.0% |
| Play in steering rack inner joint(s) Non-component advisories | 4.3% |
| Registration plates: deteriorated but not likely to be misread Identification of the vehicle | 4.0% |
| Exhaust system: mounting defective Body, chassis, structure | 3.6% |
| Sub-frame: corroded but not seriously weakened Suspension | 3.2% |
| Shock absorbers: light misting of oil Suspension | 3.1% |
Source:DVSA,UK Motoring analysis 2025 Updated
Volvo S80 problems: common questions
What is the most common problem with a Volvo S80?
Of the faults that fail an MOT, “Position lamp: not working” is the most common: it appears on 15.1% of failed Volvo S80 tests. Across categories, lamps, reflectors and electrical equipment is the area that most often fails one, on 45.4% of failed tests.
How often does a Volvo S80 fail its MOT?
31.0% of Volvo S80 tests in 2025 were not passed first time, from 6,207 tests of cars aged three and over. Allowing for the age and mileage of the cars tested, that gives it a UK Motoring Reliability Score of 60 out of 100, where 50 is as expected.
Does anything fail more often on a Volvo S80 than on other cars?
Yes. “Tyres: ply or cords exposed” appears on 7.0% of its failures against 4.1% for cars of the same age, and “Headlamp aim: too low” appears on 6.8% of its failures against 4.0% for cars of the same age. Where an item is missing from the national figures for a year, we use the smallest share those figures show, so the comparison never overstates the difference.
Are these the same as breakdowns or known faults?
No. These are the items a tester recorded at the MOT, which covers condition and safety: lamps, brakes, tyres, suspension, corrosion and emissions. A gearbox that is unpleasant, an infotainment screen that has died, or a car that will not start on a cold morning are not part of the test, so they are not in these figures.
Where do the figures come from?
Every normal MOT test of a Volvo S80 aged three and over in Great Britain in 2025, from DVSA's anonymised MOT results. Retests are excluded, and the same fault on more than one wheel counts once.
Data stories to read next
Data sources and methodology
| Figures | Source | Period | Records | Updated |
|---|---|---|---|---|
| MOT defects and advisories | Anonymised MOT tests and results Driver and Vehicle Standards Agency Derived statistics UK Motoring | 2025 | 6,207 MOT tests | 19 September 2026 |
- Shares for defects are of failed tests; shares for advisories are of all tests. A test can carry several defects, so shares add to more than 100%.
- The expected share is what an average car of the same registration years records, weighted by where this model’s failures fall. Where an item is outside the national figures for a year, the smallest share those figures show is used in its place, which is an upper bound, so the comparison never overstates a model’s problems. No expectation is published where less than 80% of the model’s failures can be compared.
- Great Britain only: DVSA does not run MOT testing in Northern Ireland. Cars under three years old are not tested.
- The descriptions of what each part does are general and the same on every model. Every figure comes from the MOT data.
Contains public sector information licensed under the Open Government Licence v3.0.